Characteristics of Asphalt Mixed Using Mountain Stone
Abstract
Aggregate is the main thing in asphalt mixtures with a percentage of about 70% to 80%. The aggregate used should meet the Indonesian National Standard (SNI) before being used in the asphalt mixture. East Kalimantan Province is one of the provinces in Indonesia which always brings in aggregates from outside the region for road construction. This study aims to analyze the modulus of stiffness of the AC-WC mixture using local aggregate of East Kalimantan Province and petroleum bitumen grade 60/70 as a binder due to water immersion. This research is experimental in the laboratory. The variation of the petroleum bitumen content used was 4.5, 5.0, 5.5, 6.0 and 6.5%. Water immersion was carried out at the age of 3, 5 and 7 days. The results showed that at 3 days of immersion, the resilient modulus values obtained at petroleum bitumen content of 4.5, 5.0, 5.5, 6.0 and 6.5% were 421.0, 506.0, 872.5, 747.0 and 648.5 MPa, respectively. At 5 days immersion, the resilient modulus values obtained were 383.5, 386.0, 915.5, 561.0 and 555.5 MPa, respectively. Whereas for the 7 days immersion, the resilient modulus were 290.5, 425.5, 1369.0, 547.5 and 525.0 MPa, respectively. It can be seen that water immersion greatly affects the stiffness modulus of the asphalt mixture. This stiffness will cause the asphalt mixture to be easily damaged or cracked. This can be caused by the influence of the sub-standard aggregates used, namely Senoni stone and Mahakam sand.
Doi: 10.28991/cej-2021-03091652
Full Text: PDF
Keywords
References
PSDG-ESDM-RI. Report on Updating Data and Balance of Mineral Resources, (2013) (in Indonesia).
Eswan, S A Adisasmita, M I Ramli, and S Rauf. “The Effect of Water Immersion on Compressive Strength of Senoni Stone, East Kalimantan.” IOP Conference Series: Earth and Environmental Science 419 (February 8, 2020): 012103. doi:10.1088/1755-1315/419/1/012103.
H. R. Anwar Yamin. “Utilization of Fak Fak Crystalline Rocks for Asphalt Mixtures.” Road and Bridge Research and Development Center (2011) (in Indonesian).
Haghshenas, Hamzeh F., and Robert C. Rea. “In-Place Density of Asphalt Pavements: Case Study during Cold Weather Paving.” Journal of Transportation Engineering, Part B: Pavements 145, no. 4 (December 2019): 05019003. doi:10.1061/jpeodx.0000135.
Liu, Jenny, Sheng Zhao, Peng Li, and Steve Saboundjian. “Variability of Composition, Volumetric, and Mechanic Properties of Hot Mix Asphalt for Quality Assurance.” Journal of Materials in Civil Engineering 29, no. 3 (March 2017). doi:10.1061/(asce)mt.1943-5533.0001481.
Tjaronge, M. Wihardi, and Rita Irmawaty. "Influence of Water Immersion on Physical Properties of Porous Asphalt Containing Liquid Asbuton as Bituminous Asphalt Binder." In Proceedings of 3rd International conference and Sustainable Construction Material and Technologies-SCTM, , Kyoto, Japan, vol. 153, (2013): M4-1.
Mohammad, Louay N., Mostafa Elseifi, Samuel B. Cooper, and Amar Raghavendra. “Levels of Variability in Volumetric and Mechanical Properties of Asphalt Mixtures.” Journal of Materials in Civil Engineering 25, no. 10 (October 2013): 1424–1431. doi:10.1061/(asce)mt.1943-5533.0000545.
Mohammad, Louay N., Zhong Wu, Chenggang Zhang, Mohammad J. Khattak, and Chris Abadie. “Variability of Air Voids and Mechanistic Properties of Plant-Produced Asphalt Mixtures.” Transportation Research Record: Journal of the Transportation Research Board 1891, no. 1 (January 2004): 85–97. doi:10.3141/1891-12.
Tumpu, M, M W Tjaronge, A R Djamaluddin, A A Amiruddin, and La One. “Effect of Limestone and Buton Granular Asphalt (BGA) on Density of Asphalt Concrete Wearing Course (AC-WC) Mixture.” IOP Conference Series: Earth and Environmental Science 419 (February 8, 2020): 012029. doi:10.1088/1755-1315/419/1/012029.
Mabui, D S, M W Tjaronge, S A Adisasmita, and M Pasra. “Resistance to Cohesion Loss in Cantabro Test on Specimens of Porous Asphalt Containing Modificated Asbuton.” IOP Conference Series: Earth and Environmental Science 419 (February 8, 2020): 012100. doi:10.1088/1755-1315/419/1/012100.
Mabui, D. S., Tjaronge, M. W., Adisasmita, S. A., and Pasra, M. “Performance of Porous Asphalt Containing Modificated Buton Asphalt and Plastic Waste.” International Journal of GEOMATE 18, no. 65 (January 1, 2020): 118–123. doi:10.21660/2020.65.67196.
Lapian, F E P, M I Ramli, M Pasra, and A Arsyad. “Opportunity Applying Response Surface Methodology (RSM) for Optimization of Performing Butonic Asphalt Mixture Using Plastic Waste Modifier: a Preliminary Study.” IOP Conference Series: Earth and Environmental Science 419 (February 8, 2020): 012032. doi:10.1088/1755-1315/419/1/012032.
Sukrislistarto, M. I. Ramli, M Pasra, and A. A. Amiruddin. “The Sustainable Performance Challenge of Asphalt Mixture Using Polypropylene Due to Environmental Weather.” IOP Conference Series: Earth and Environmental Science 419 (February 8, 2020): 012075. doi:10.1088/1755-1315/419/1/012075.
Meraudje, A., M. I. Ramli, M. Pasra, and A. A. Amiruddin. “The Potential Utilization of Polyethylene Terephthalate (PET) Waste as Fine Aggregate Replacement in Asphalt Mixture.” IOP Conference Series: Earth and Environmental Science 419 (February 8, 2020): 012036. doi:10.1088/1755-1315/419/1/012036.
Erdawaty, Erdawaty, Tri Harianto, A. B. Muhiddin, and Ardy Arsyad. “Experimental Study on Bearing Capacity of Alkaline Activated Granular Asphalt Concrete Columns on Soft Soils.” Civil Engineering Journal 6, no. 12 (November 30, 2020): 2363–2374. doi:10.28991/cej-2020-03091623.
Directorate General of Highways Department of Public Works. Construction and Building Guidelines No: 001-01/BM/2006, Utilization of Buton Asphalt: General, (2006).
Tjaronge, MW, Rita Irmawaty, and Muralia Hustim. "Effect of Buton Granular Asphalt Gradation and Cement as Filler on Performance of Cold Mix Asphalt Using Limestone Aggregate." Journal of Engineering Science and Technology 15, no. 1 (2020): 419-433.
Bulgis, M W Tjaronge, S A Adisasmita, and M Hustim. “Analysis of Stability of Residue Asphalt Emulsion Mixture Containing Buton Granular Asphalt (BGA).” IOP Conference Series: Earth and Environmental Science 419 (February 8, 2020): 012073. doi:10.1088/1755-1315/419/1/012073.
Iroth, M W, M W Tjaronge, and M. Pasra. “Influence of Short Term Oven Aging on Volumetric Properties of Asphalt Concrete Mixture Containing Modified Buton Asphalt and Limestone Powder Filler.” IOP Conference Series: Earth and Environmental Science 419 (February 8, 2020): 012072. doi:10.1088/1755-1315/419/1/012072.
Tumpu, M, M W Tjaronge, and A R Djamaluddin. “Prediction of Long-Term Volumetric Parameters of Asphalt Concrete Binder Course Mixture Using Artificial Ageing Test.” IOP Conference Series: Earth and Environmental Science 419 (February 8, 2020): 012058. doi:10.1088/1755-1315/419/1/012058.
Tayfur, Süreyya, Halit Ozen, and Atakan Aksoy. “Investigation of Rutting Performance of Asphalt Mixtures Containing Polymer Modifiers.” Construction and Building Materials 21, no. 2 (February 2007): 328–337. doi:10.1016/j.conbuildmat.2005.08.014.
Birgisson, B., A. Montepara, E. Romeo, R. Roncella, J.A.L. Napier, and G. Tebaldi. “Determination and Prediction of Crack Patterns in Hot Mix Asphalt (HMA) Mixtures.” Engineering Fracture Mechanics 75, no. 3–4 (February 2008): 664–673. doi:10.1016/j.engfracmech.2007.02.003.
Hunter, Robert N., Andy Self, John Read, and Elizabeth Hobson. “The Shell Bitumen Handbook.” London, UK: ICE Publishing, (2015).
Mahyuddin, Abrar, M. W. Tjaronge, Nur Ali, and M. Isran Ramli. "Experimental analysis on stability and indirect tensile strength in asphalt emulsion mixture containing Buton granular asphalt." International Journal of Applied Engineering Research 12 (2017): 3162-3169.
Gaus, A., M. W. Tjaronge, N. Ali, and R. Djamaluddin. "Experimental Study on Characteristics of Asphalt Concrete Bearing Coarse (AC BC) Mixture using Buton Granular Asphalt (BGA)." International Journal of Applied Engineering Research 9, no. 22 (2014): 18037-18045.
Gaus, Abdul, Tjaronge M.W., Nur Ali, and Rudy Djamaluddin. “Compressive Strength of Asphalt Concrete Binder Course (AC-BC) Mixture Using Buton Granular Asphalt (BGA).” Procedia Engineering 125 (2015): 657–662. doi:10.1016/j.proeng.2015.11.097.
Budiamin, Tjaronge MW, S. H. Aly, and R. Djamaluddin. "Mechanical characteristics of hotmix cold laid containing buton granular asphalt (BGA) and flux oil as wearing course." ARPN Journal of Engineering and Applied Sciences 10, no. 12 (2015): 5200-5205.
Bulgis, M W Tjaronge, S A Adisasmita, and M Hustim. “Effect of Buton Granular Asphalt (BGA) on Compressive Stress-Strain Behavior of Asphalt Emulsion Mixture.” IOP Conference Series: Materials Science and Engineering 271 (November 2017): 012069. doi:10.1088/1757-899x/271/1/012069.
Lapian, Franky E. P., Muhammad Isran Ramli, Mubassirang Pasra, Ardy Arsyad, and Hajriyanti Yatmar. “Application of Surface Response Methodology (RSM) for Improving the Marshall Quotient of AC-WC Mixtures Containing PET Plastic Waste.” ICCOEE2020 (2021): 966–975. doi:10.1007/978-981-33-6311-3_109.
Tjaronge, M W, Fakhruddin, M A Caronge, M H Zaifullah, and M F Rahmat. “Preliminary Study on Compressive Strength of Porous Asphalt Containing Modified Buton Asphalt, Waste Plastic and Limestone Powder.” IOP Conference Series: Materials Science and Engineering 875 (July 23, 2020): 012032. doi:10.1088/1757-899x/875/1/012032.
Asphalt Institute. “The asphalt handbook.” College Park, MD: Asphalt Institute, (2007).
Carbonneau, Xavier, Yves Le Gal, and Pierre Bense. "Evaluation of the indirect tensile stiffness modulus test." In Sixth International RILEM Symposium on Performance Testing and Evaluation of Bituminous Materials, RILEM Publications SARL, (2003): 308-315.
Baskara, Gusti Made Bagus, Ervina Ahyudanari, and I. Nyoman Arya Thanaya. "Analysis of Stiffness Modulus of Asphalt Concrete Mixture by Using Artificial Aggregates." Jurnal Teknik ITS 8, no. 2 (2019): F81-F85.
Directorate General of Bina Marga, Ministry of Public Works 3rd Revision, 2010, Spesifikasi Umum Jalan dan Jembatan, Bina Marga (in Indonesian).
British standards (BS EN 12607-26: 2012). Method for Determination of the indirect tensile stiffness modulus of bituminous mixtures.
DOI: 10.28991/cej-2021-03091652
Refbacks
- There are currently no refbacks.
Copyright (c) 2021 Eswan Eswan
This work is licensed under a Creative Commons Attribution 4.0 International License.
